Tek-Tips is the largest IT community on the Internet today!

Members share and learn making Tek-Tips Forums the best source of peer-reviewed technical information on the Internet!

  • Congratulations cowski on being selected by the Eng-Tips community for having the most helpful posts in the forums last week. Way to Go!

Plugging a simple ac-ac transformer (wall power pack) into an inexpensive UPS

Status
Not open for further replies.

HighPotential

Electrical
Joined
Sep 24, 2002
Messages
50
Location
US
A little out of my league here but I would think harmonics would cause the power transformer to heat more and possibly fail prematurely.

The UPS is a simple, personal computer style unit (such as an APS) and is not true sine wave. We are talking maybe 30% distortion.

The power pack is about 2A 120VAC.
 
Many, many factors weigh into the severity but fundamentally yes, you're correct.

The AC resistance of the coil (mostly due to skin effect but also proximity effects) may be a bit higher at the harmonics causing additional winding losses. I doubt this will be particularly significant since the frequencies are probably still quite low. The other source of loss is core loss mainly due to hysteresis loss and eddy current loss. The severity of this loss has a lot to do with the transformer core construction and is to estimate. Again, I suspect the effect might be low.

So to be sure you'd need to carefully inspect the voltage spectrum at the output of the UPS and carefully consider the specifications of the transformer. Or you could just measure it. My hunch is that there would be a small but noticeable difference in heat produced. Curious to know more.
 
Personally, I'd compare the temperature rise of the wall wart when plugged into the mains vs. the UPS. Yes, the "modified sine wave" from the UPS will almost certainly cause the transformer in the wall wart to run hotter, but if that only causes the case temperature to increase from, say, 50C to 60C, I probably wouldn't sweat it... Bad pun intended.
 
Status
Not open for further replies.

Part and Inventory Search

Sponsor

Back
Top