Tek-Tips is the largest IT community on the Internet today!

Members share and learn making Tek-Tips Forums the best source of peer-reviewed technical information on the Internet!

Register Log in
  • Congratulations cowski on being selected by the Eng-Tips community for having the most helpful posts in the forums last week. Way to Go!

Recent content by DeltaCascade

  1. DeltaCascade

    ppm of Chemical dosing

    That's a tough question Nad87. Folk are trying to help you so it would be helpful in return if you were more specific and less philosophical. MJCronin is bang on with all his answers. Take the advice, be grateful, and come back with specific questions. pierreick, too, the old Betz...
  2. DeltaCascade

    BA AND CA SULPHATES REMOVAL BEFORE RO ??

    Alternately, waste the demin plant effluent as it may be about as, if not more, concentrated than RO reject waste water (there's nothing like a component mass balance to tell you that .. but it is work). You can recycle a portion of demin plant regen rinse waters which is of good quality...
  3. DeltaCascade

    "Brine Maker" or "Brine Saturator" Design Guide

    Thank you, very much. Those where the two best references found, too. Missing, I tought, was minimum salt depth for the capacities given, yet, after looking again, 5 ft appears to be the recommended minimum (eg: 15 tonne for granulated salt in a 10' diameter tank). I guess we could assume...
  4. DeltaCascade

    "Brine Maker" or "Brine Saturator" Design Guide

    Hello: After searching high and low, it is surprising to find little information on Brine Saturator Tank design for industrial duty brine-production for ion-exchange (sodium zeolite) water softener regeneration. Can anyone contribite a detailed design guide or technical reference? Many...
  5. DeltaCascade

    How big can a FRP HCl (36%) storage tank be built?

    You can consult the Chlorine Institute's Pamphlet #163, "Hydrochloric Acid Storage and Piping Systems" for tank design details. This appears to be the "authority" on the issue. The pamphlet states that 15,000 gallons and above, use rubber lined steel tank, otherwise, if smaller, FRP can be...
  6. DeltaCascade

    Tank freeze protection for irregular operation

    Consider hiring a professional engineer to (help) design the tanks. Perhaps Perry's handbook of chemical engineering will help. Perhaps your tank vendor has the staff on hand. As our fellow commentators suggested, options appear to be heat tracing, heating coils, bayonette heater, or heat...
  7. DeltaCascade

    Pressure of stream to a tank

    Your concern is likely with superheat of the steam. If the steam does not condense in the short rise of 5 m, it will vent. For safety, assume no condensation as a first approximation, at least, regardless of how much sparging and mixing you may do. Also, once the water gets to boiling, all the...
  8. DeltaCascade

    Methanol Storage, venting

    Also see recomended practice of API-2000, ... Tank Venting Requirements
  9. DeltaCascade

    Demin water tank - nitrogen blanketing

    Is the demin water for boiler make-up water supply, only, or other purpose? You had said before that oxidation was a concern, which to me means corrosion from dissolved oxygen (demin water is particularly agressive this way). This is just said, as, if you calculated CO2 adsorption into demin...
  10. DeltaCascade

    Demin water tank - nitrogen blanketing

    So, why are you considering blanketing? The demin water entering the tank is already saturated with air (dissolved oxygen), is it not? So blanketing will make no difference at the tank ... unless the water entering the tank was already deaerated? PS; Demin water tank is likley large, not...
  11. DeltaCascade

    Demin water tank - nitrogen blanketing

    WOAH! It appears that you want to nitrogen blanket to keep dissolved oxygen out so that the demin water won't become corrosive to carbon steel tank? (it is after all, upstream of your deaerator(s)) 10 ppb dissolved oxygen makes demin water surprisingly corrosive. At room temperature, about 10...
  12. DeltaCascade

    Cooling Tower Water Treatment with polymers

    Yeah ... if you shut in a typical industrial cooling tower's blowdown, even on a calm day, you could only get to about 15 cycles of concentration. That is due to drift, liquid water droplets leaving with warmed air out through the induced draft fan blades... about 0.05 % of recirc flow .. which...
  13. DeltaCascade

    Carbon Dioxide (CO2) Solubility in Water

    Water quality used will be key due to formation of carbonic acid: CO2 + H2O <==> H2CO3 If you neutralize the acid, it will increase the carbonate loading achievable. Stripping towers to remove CO2 from water (after an acid cation ion exchange bed in water demineralization plans) are likely more...
  14. DeltaCascade

    COMMISSIONING PLAN & PROCEDURE FOR CHLORAMINATION WATER TREATMENT

    Ask the manufacturer?
  15. DeltaCascade

    Lime Softening Calc Software?

    It turns out that AWWA (American Water Works Association) also has some software available for members, including lime - soda softening material balances.
See more

Part and Inventory Search

Back
Top